Report: 4 companies selling new cars with Takata inflators
Four automakers are selling new vehicles with Takata air bag inflators even though the devices are potentially defective and likely to be recalled within a few years, according to a Senate report.
Some Fiat Chrysler, Mitsubishi, Toyota and Volkswagen vehicles from the 2016 and 2017 model years are equipped with a type of inflator that is prone to rupture and presents a potential danger to drivers and passengers, Democrats on the Senate Commerce Committee said in the report issued Wednesday.
Takata has agreed to recall about 69 million air bag inflators in the U.S. by the end of 2019. The new model years aren't yet covered by the recall, so the automakers can legally sell the cars. But at least one lawmaker thinks that decision is a risky one for car buyers.
"Consumers are buying new cars not realizing that they're going to be recalled," said Sen. Bill Nelson of Florida, the Commerce committee's top Democrat. Nelson wants the automakers to replace the inflators before the cars are sold so they don't have to be recalled.
The problematic inflators contain ammonium nitrate, which can deteriorate over time when exposed to moisture and high temperatures. The National Highway Traffic Safety Administration has said that its tests show it takes at least six years before the inflators pose a danger.
Takata Corp. has agreed to recall all original equipment inflators that lack a chemical drying agent in phases by the end of 2018. So far, the recall affects 17 car and truck companies, with vehicles going back to the 2000 model year.
At least 11 people have been killed worldwide by Takata's inflators. Two other deaths in Malaysia are under investigation.
Mitsubishi and Volkswagen identified the new models that have Takata inflators without the drying agent. They include the 2016 Volkswagen CC, 2016 Audi TT, 2017 Audi R8, and the 2016 and 2017 Mitsubishi i-MiEV. Toyota and Fiat Chrysler did not specify models.
According to the report, Toyota said it expects to make about 175,000 unspecified vehicles with defective Takata inflators from March 2016 to July 2017. Messages were left seeking comment from Toyota.
Fiat Chrysler has only one new model with the inflators, which spokesman Eric Mayne declined to identify. "These vehicles are not currently subject to recall. They meet or exceed all applicable safety requirements," Mayne said in an email.
The Democrats' report says completion rates for the Takata recall remain low. As of March, Honda led with almost 40 percent of inflators replaced, while Daimler Vans had completed only 0.4 percent.
NHTSA said in a statement that it has called on automakers to do more to notify vehicle owners and speed up replacement of the Takata inflators.
The report also says that a majority of replacement inflators that have been installed, about 4.6 million, are made by Takata and use ammonium nitrate. At least 2.1 million of those don't have the drying agent and will have to be recalled again.
NHTSA has said there are 85 million unrecalled Takata inflators in U.S. vehicles, some with and some without the drying agent. Takata has until the end of 2019 to prove that inflators with the drying agent are safe, or they must be recalled as well.
(Copyright 2016 The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.)